CG125 headlight bulb fusing

123rfaa (123rfaa) 2019-08-02 01:23:22 +0500 #1

Hello everyone,

I need to discuss an issue i am facing with my bike it's headlight bulb is fusing after running it on high rev the bulb just goes brighter and then starts to fade and boom it's gone. already tried changing good quality bulbs. Battery is in good condition bulb holder also looks good. Got it checked from a mechanic and he said this could be an issue with rectifier i just need to make sure if that it is. also another strange thing happened last night was that it was raining and there was more than normal water everywhere on the roads so when i passed through it and after a few meters of passing through the bike started missing really badly i am sure there was not water mixed up in the petrol tank there was nothing wrong with the plug but bike will just not pick race after trying to ride it for around 10 minutes the missing went away and it ran like a charm but after again i had to cross the road with a little bit more water than normal after a few meters is started doing the same thing and after a couple of minutes missing went away. I highly doubt this a wiring issue somewhere can you guys please help me out in this case? thanks in advance.

pwuser154250632795 (Nawazish Hussain) 2019-08-03 23:30:03 +0500 #2

Faulty rectfire/regulator for bulb fusing.

user-xxx (user-xxx) 2019-08-10 11:46:10 +0500 #3

if its at higher reves than check the current limiter device its below the seat attached on the top of rear mudguard.

It limits the current of CG and its only present in CG

pwuser15663629912 (Zahid Prince) 2019-08-30 16:19:34 +0500 #4

Bhai plug adopter wet hota hai jab bhi ap barish ya wet place se jatay ho.phir wo missing kerta hai.aur jab dry hota hai to thek hota hai.byc wash karanay k bad bhi jab tek dry na ho missing kerta hai.so its normal

umairafzalrana (UMAIR AFZAL) 2019-08-30 17:26:29 +0500 #5

Rectifier/relay change krao...
Thek ho jaey ga.
Aur kuch b nhi krana.

123rfaa (123rfaa) 2019-11-07 23:06:56 +0500 #6

Thanks for the replies guys.
The bike is running fine since it is not raining for being a long time here also i didn't got the bike serviced or washed the strange thing is the bulb is not fusing too even on higher revs, One thing i need to add the bike light gets a little brighter when i apply breaks also the turn signals are flashing much faster then normal flashing.